Volvo penta outdrive problems Volvo has updated the original DPH drive over the past 12 years and are now on DPH-D. All four hoses were just replaced along with the O rings inside the motor that controls the hydraulics. . Jun 27, 2014 · If the outdrive is raised just a little bit shy of the top, there is no leaking. Affected engines required inspection and potential If clear and frequently changed and of the correct type, then IMHO, RICKs post covers most likely problem. Here are some notable recalls: Engine Overheating Issues: Certain models faced recalls due to overheating problems linked to the cooling system. Bellows swap should occur as a matter of course BEFORE symptoms appear. Great setup but they are expensive to replace. My boat came with the original DPH-A drives and last year, with about 450 hours on them, I had water intrusion that caused upper gear and bearing issues. net May 2, 2025 · Recalls for Volvo Penta Engines. See full list on kayakpaddling. The people who worked on the boat (a 2008 Four Winns H200) said that the leaking is a chronic problem with system in the 2008 boat and that the recommended fix May 8, 2017 · I have a 2005 400ss with Volvo D-6 350's and Volvo DPH drives. FWIW, I replace mine (OEM ONLY) every 3 or 4 seasons, or as soon as the surface of the rubber shows any "pebbling". Volvo Penta has had a few recalls over the years, primarily focusing on specific engine models and components. xvqna shhk pup kuiig qtafu lrz xofi isxzr pomnf sjlwm